Powermate P1204 User Manual

© 2007 Powermate Corporation Stationary Standby Electric GeneratorIMPORTANT SAFETY INSTRUCTIONS – Please make certain that persons who are to install

200-266710When connecting the generator to a buildingelectrical distribution system, use of a transfer switch isrecommended to isolate the normal util

11200-2667Once the generator is anchored in its final position, itis ready for electrical connections. The generator issupplied with two terminal blo

200-266712A receptacle is provided with the generator to powerthe battery charger for reliable starting. It is alsointended to power an optional bloc

13200-2667WWIIRRIINNGG DDIIAAGGRRAAMM

200-266714The engine driving the generator is engineered toprovide reliable power on either Liquefied Propane Vapor(LPG) or Natural Gas. For proper op

15200-2667Units are tested with natural gas before they leavethe factory. If natural gas is to be used, no adjustmentsare required.When supplying natu

200-266716To insure reliable starting in most weatherconditions, it is important to properly match a battery tothe requirements of the generator. The

17200-2667To access the battery and charger, remove the frontand back panels by inserting the key into the lockslocated on top of the panel. and turn

200-266718After completing all installation procedures, read andunderstand the operating instructions for the generatorcontroller. Know how the contr

19200-2667A. MODE BUTTONS (AUTO, MANUAL AND OFF)B. AUTO LEDC. STATUS INDICATOR LED’sD. UTILITY POWER MONITOR LEDE. TRANSFER SWITCH MONITOR LEDF. GENER

200-26672Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

200-266720RUN MODESThere are three run mode options: Off, Manual andAuto. When the Manual pushbutton is pressed the unitwill immediately start and the

21200-2667Status indicator LED’s relay conditions of generatorfunction for user or service technician convenience.Illumination of these indicator LED’

200-266722MMMMAAAAIIIINNNNTTTTEEEENNNNAAAANNNNCCCCEEEETo ensure reliable generator operation, it is critical toperiodically inspect all components. T

23200-2667Prior to checking the oil level, start the generator bypressing the MANUAL Mode button on the control panel.Allow the generator to run for o

200-266724Selection of the correct grade and type of engine oilgreatly affects the performance of the generator,especially when starting. Before sele

25200-2667The generator engine is equipped with a dry elementair filter to block particles in the combustion air fromgetting into the engine and causi

200-266726Engine spark plugs are an important part of theengine ignition system. Worn or incorrectly adjustedspark plugs can negatively affect engine

27200-2667Proper cooling of the generator is vital to maintainperformance and prevent equipment failure. Blockedcabinet openings or other airflow obs

200-266728TTTTRRRROOOOUUUUBBBBLLLLEEEESSSSHHHHOOOOOOOOTTTTIIIINNNNGGGGSYMPTOM POSSIBLE CAUSE CORRECTIVE ACTIONEngine does not crankLoose battery cable

29200-2667TTTTRRRROOOOUUUUBBBBLLLLEEEESSSSHHHHOOOOOOOOTTTTIIIINNNNGGGGSYMPTOM POSSIBLE CAUSE CORRECTIVE ACTIONLow generator outputvoltageExcitation ca

3òÿåDo not attempt to install the generator yourself. Extremely high and dangerous electrical voltages are present in utility power source lines and i

200-266730NNNNOOOOTTTTEEEESSSS

31200-2667POWERSTATION®Automated Power SystemLimited WarrantyWarranty: Powermate Corporation warrants to the original consumer purchaser in the U.S. o

CONTACT THE POWERMATE PRODUCT SERVICE DEPARTMENT AT1-866-769-3703to obtain warranty service information or to order replacement parts or accessories.H

200-26674The National Electrical Code (NEC) requires the frame and external electrically conductive parts of the generator to be connected to an appro

5200-2667The stationary standby electric generator ismanufactured for our customers to supply reliablebackup power. The generator is a compact unit,d

200-26676GGGGEEEENNNNEEEERRRRAAAATTTTOOOORRRR SSSSPPPPEEEECCCCIIIIFFFFIIIICCCCAAAATTTTIIIIOOOONNNNSSSSP120401 (12 KW)Rated Wattage - (Standby) @1.0 P

IIIINNNNSSSSTTTTAAAALLLLLLLLAAAATTTTIIIIOOOONNNN DDDDRRRRAAAAWWWWIIIINNNNGGGGSSSS7200-2653

200-26678Once installation planning is complete and allnecessary local permits are granted, installation of thegenerator may begin. Within the follow

9200-2667The generator is supplied with an integral moldedplastic base for use as an installation pad. Use of thisbase is intended to minimize install